Authors' objectives: Surgical wounds healing by secondary intention occur if a surgical wound is not closed or dehisces following primary closure. Surgical wounds healing by secondary intention are common and adversely affect patients’ quality of life. Treatment is often prolonged, complex and expensive. Negative pressure wound therapy applies a controlled vacuum to the wound and is increasingly used to promote surgical wound healing by secondary intention despite limited rigorous evidence for the clinical and cost-effectiveness of negative pressure wound therapy to augment surgical wound healing by secondary intention. Assess the clinical and cost-effectiveness of negative pressure wound therapy versus usual care (no negative pressure wound therapy) in treating surgical wounds healing by secondary intention.

Authors' results and conclusions: Between 15 May 2019 and 13 January 2023, 686 participants were recruited, randomised and included in the analysis (negative pressure wound therapy n = 349; usual care n = 337). Most participants had a single surgical wound healing by secondary intention (n = 622, 90.7%), located on the foot (n = 551, 80.3%) or leg (n = 69, 10.1%) arising following vascular surgery (n = 619, 90.2%). Most participants had comorbidities; diabetes (n = 549, 80.0%), cardiovascular disease (n = 446, 65.0%) and/or peripheral vascular disease (n = 349, 50.9%). Median time to healing was 187 days (negative pressure wound therapy) versus 195 days (usual care), with no evidence that negative pressure wound therapy reduced the time to wound healing compared to usual care (hazard ratio 1.08, 95% CI 0.88 to 1.32; p = 0.47). Odds of re-admission, reoperation, surgical site infection and antibiotic use were slightly higher, and odds of amputation or death slightly lower for negative pressure wound therapy participants. These results were not clinically or statistically significant. Bluebelle Wound Healing Questionnaire, quality of life and wound pain scores were not statistically significantly different at any time point. Serious adverse events were rare (nine negative pressure wound therapy vs. five usual-care participants). Both cost-effectiveness analyses concluded that negative pressure wound therapy generates higher costs and marginally higher quality-adjusted life-years than usual care, although findings were statistically insignificant. The probability of negative pressure wound therapy being cost-effective was under the recommended National Institute for Health and Care Excellence cost-effectiveness thresholds. The Bluebelle Wound Healing Questionnaire was acceptable to participants, had low levels of missing data and demonstrated good levels of sensitivity and specificity in the detection of surgical site infection in surgical wounds healing by secondary intention. Negative pressure wound therapy is not clinically or cost-effective in augmenting healing in patients with surgical wounds healing by secondary intention, particularly those with comorbidities.

Authors' methods: A pragmatic, two-arm, parallel-group, randomised controlled superiority trial. Twenty-eight UK NHS Trusts randomised adult patients with a surgical wounds healing by secondary intention to receive negative pressure wound therapy or usual care (no negative pressure wound therapy). The planned sample size was 696 participants. Participants were followed up for 12 months via weekly telephone contact to collect the primary outcome (time to healing: full cover with no scab in days since randomisation) and clinical secondary outcomes: wound healing, surgical site infection, pain, hospital re-admission, current treatment and reasons for treatment change (if applicable), reoperation, amputation, antibiotic use, death. Patient-reported outcomes (pain, health-related quality of life and resource use) were collected by postal questionnaire at 3, 6 and 12 months. Validation of the Bluebelle Wound Healing Questionnaire, a patient-reported measure of surgical site infection, was also undertaken. A cost-effectiveness decision model considering all available evidence, and a within-trial cost–utility analysis, was also undertaken to evaluate the cost-effectiveness of negative pressure wound therapy against usual care. Neither participants nor the investigators were blind to treatment allocation. The trial included a high proportion of diabetic participants with foot wounds, which may affect study generalisability. Negative pressure wound therapy use for ‘wound management’, common in certain surgical specialties, was not assessed in this study.

Project Status: Completed

URL for project: https://www.journalslibrary.nihr.ac.uk/programmes/hta/17/42/94

Year Published: 2026

URL for published report: https://www.journalslibrary.nihr.ac.uk/hta/GJIC1716

URL for additional information: English

English language abstract: An English language summary is available

Publication Type: Full HTA

Country: England, United Kingdom

DOI: 10.3310/GJIC1716

Organisation Name: NIHR Health Technology Assessment programme

Contact Address: NIHR Journals Library, National Institute for Health and Care Research, Evaluation, Trials and Studies Coordinating Centre, Alpha House, University of Southampton Science Park, Southampton SO16 7NS, UK

Contact Name: journals.library@nihr.ac.uk

Contact Email: journals.library@nihr.ac.uk